fbpx
Print this page
Saturday, 28 November 2015 10:25

Blitz brings energy efficiencies

Written by  Pam Tipa
Fonterra’s energy manager Tony Ooston. Fonterra’s energy manager Tony Ooston.

Energy blitzes at Fonterra's 36 sites identified 900 initiatives for energy efficiency, says Fonterra energy manager, Linda Thompson.

The ongoing energy programme began in 2003, cutting the co-op's 'energy intensity' by 16.8%, calculated on the gigajoules of energy per tonne of product made, says Thompson. That saving is equivalent to two years' annual household use by all Wellington houses.

The sites are audited against best practice and on the principles of the ISO 5001 standard for energy management, covering, for example, energy consumption, contracts and management.

From those blitzes about 900 initiatives were identified, implemented at the sites and ranked from the biggest benefit down. Last season they took a slightly different approach and looked at target plants including Te Awamutu and Te Rapa. At Te Awamutu they make dual use of water already heated.

Tony Ooston, also a co-op energy manager, says on the boilers at Pahiatua, built last year, and Lichfield, under construction, they have installed high-efficiency economisers that extract every last bit of heat. The economisers are the biggest in New Zealand for the size of the gas-fired boilers. That heat extraction also cuts gas consumption. The plant achieves 93% energy efficiency vs 87% in a typical boiler.

They are now looking at retro-fit possibilities at other plants, starting with cost-benefits.

Longburn, Tuamarina and Culverden are concentrate plants where water is extracted from milk before it is sent to manufacturing plants, thus saving energy in transport. The water is reused.

Oosten says the Edendale plant has expanded production, but by raising energy efficiency they haven't had to increase boiler capacity. "All we've had to do is balance the heat load at the site and utilise existing assets."

Mark Leslie, Fonterra director, NZ manufacturing, says there is not one big 'silver bullet' for energy efficiency; instead lots of little things stack up. The concentrate sites are one example: concentrated milk requires less fuel to move it. Tuamarina and Culverden are 250km from the nearest plant so it creates energy efficiency.

Last year they concentrated milk at Longburn then railed it south across Cook Strait to Clandeboye. Lighting design also raises energy efficiency.

Thompson says computer analysis determines the most efficient routes for milk collection; since 2010 they have cut diesel use by 10% per 100km tanker running. The schedules are optimised every 12 hours using a predictive analysis of the volumes produced at each farm.

Oosten says 40% of the milk is picked up in the three peak months, this season 87 million litres, equating to a farm collection every eight-nine seconds.

Leslie says they ship products to China and 146 other countries as energy efficiently as possible.

Fonterra has 2500 inspections a year by regulatory authorities and customers, and energy efficiency is an increasingly hot topic.

More like this

Fonterra's in good shape

Fonterra released its interim results last month, showing a continuation of the strong earnings performance delivered by the co-op through the 2023 financial year. Here’s what Fonterra chair Peter McBride and chief executive Miles Hurrell said about the results…

China trade

OPINION: Last week's revelation that data relating to New Zealand MPs was stolen amid Chinese state-sponsored cyber espionage targeting two arms of the country’s Parliament could test the long-standing trade relations between the two countries.

Featured

Editorial: War's over

OPINION: In recent years farmers have been crying foul of unworkable and expensive regulations.

NZ-EU FTA enters into force

Trade Minister Todd McClay says Kiwi exporters will be $100 million better off today as the NZ-EU Free Trade Agreement (FTA) comes into force.

Deer industry tackling integrated farm planning

Making things simpler, not harder, for deer farmers in farm planning and coping with regulations is Deer Industry New Zealand (DINZ) industry capability manager John Ladley’s current focus.

Online business directory for rural women

Rural Women New Zealand (RWNZ) is launching an online business directory called The Country Women’s Collective to promote and support entrepreneurial rural women.

National

Council lifeline for A&P Show

Christchurch City Council and the Canterbury Agricultural and Pastoral Association (CAPA) have signed an agreement which will open more of…

Struggling? Give us a call

ASB head of rural banking Aidan Gent is encouraging farmers to speak to their banks when they are struggling.

Machinery & Products

New name, new ideas

KGM New Zealand, is part of the London headquartered Inchcape Group, who increased its NZ presence in August 2023 with…