Friday, 20 March 2020 12:53

Don’t be bullied into building large ponds

Written by  Staff Reporters
Do you really need a large effluent pond? Do you really need a large effluent pond?

A Hamilton soil and water consultant is questioning the effectiveness of the dairy effluent storage calculator on Waikato farms.

Fred Phillips, a natural resource engineer, says Waikato soils are hugely variable and there are large areas of free draining sandy loams and ash soils that are extremely low-risk when it comes to effluent management. 

The Waikato also has large areas of what were originally classed as peat soils, the vast majority of which have been drained over the last 80 years and are now organic loams and are likely to be low-risk soils despite being classed as High-risk peat bogs.

Massey, AgResearch and Horizons Regional Council developed a dairy effluent storage calculator to help farmers plan storage to cope with wet weather and heavy clay soils, so that effluent could be stored when soil conditions were likely to give rise to excessive drainage and subsequent discharge into streams.

Phillips says they also included a category for low-risk soils for farmers who were not on the heavy clay soils of the Manawatu or the marine clays common in the Hauraki.

“Having designed the DESC Massey and AgResearch staff had done what they were contracted to do and DairyNZ took over responsibility for the model and successfully marketed its environmental benefits to other regional councils all over NZ so that it has now become the “Bible”,” he says.

“Unfortunately computer models are not biblical and as additional experience and information becomes evident, computer models need to be upgraded and tuned to be more appropriate for the range of conditions encountered.

It is even more important when a programme is designed as a management guide is grabbed by councils and used as a blanket enforcement tool. It happened with Overseer and it has happened with the DESC.

“Councils and dairy companies are on the band wagon telling farmers that they must comply with the DESC. The fact that a person can be successfully prosecuted for not complying with a rule is a lot easier than proving that a person is damaging the environment.”

Phillips notes that many Waikato farmers have been doing an excellent job in relation to effluent management for more than 25 years.

This has been achieved with modest sprinkler and pump systems pumping from small sumps adjacent to the cow yard and irrigated directly onto pasture as soon as the effluent is produced during the washdown process.

He says this has worked well because the Waikato region has been blessed with a range of free-draining soils from sandy loams near the major river systems and vast areas of volcanic ash soils as a result of volcanic eruptions. 

Many of these soils have natural infiltration rates well in excess of 15mm/hour.

Farmers who look after these precious soils can apply effluent at up to 15 mm per hour without any risk of ponding, almost every day of the year, he says.

“At lower application rates they are even more secure.

“When the DESC was applied to these very low-risk soils, it became very obvious that the DESC was predicting storage volumes that were excessive, because the very low risk soils had not been identified as an important issue.

“It has taken four years of debate and discussion for it to be accepted that the DESC was not providing fit for purpose advice for farmers with these highly productive and free draining soils.”

Phillips says farmer experience and comparative advantage were being pushed aside and Waikato farmers were being told to invest millions of dollars over and above what was actually needed, to be good law abiding custodians of our land and water. 

“It is fair to say that these people have been bullied by well-intended people who did not have the appropriate personal knowledge and experience in soil and water to make judgement calls, but they could look up maps and models on a computer, even if they did not know how to use a spade as a validation or an investigative tool.” 

Six key factors

According to Fred Philips, there are six key factors that determine the storage requirements for effluent. 

• The area of concrete draining to the effluent sump, 

• The amount of water used for washing down,

• The Volume of effluent you are prepared to apply on any day after wet weather,

• The soil characteristics and infiltration rate,

• The sprinkler application rate (this is where the rubber meets the road),

• And how you manage and maintain your system. 

More like this

$52,500 fine for effluent mismanagement

A Taupiri farming company has been convicted and fined $52,500 in the Hamilton District Court for the unlawful discharge of dairy effluent into the environment.

Fliegl offers effluent solutions

Founded in Germany as recently as 1977, today, the Fliegl Group employs more than 1100 workers, offering an expansive range of transport solutions, from their base in Bavaria.

Featured

NZ seeks certainty on US tariff, says McClay

Trade Minister Todd McClay says his officials plan to meet their US counterparts every month from now on to better understand how the 15% tariff issue there will play out, and try and get some certainty there for our exporters about the future.

Trial shows benefits of spring nitrogen use

A landmark New Zealand trial has confirmed what many farmers have long suspected - that strategic spring nitrogen use not only boosts pasture growth but delivers measurable gains in lamb growth and ewe condition.

Eric Roy: Championing the pork industry

It was recently announced that former MP and Southland farmer Eric Roy has stepped down of New Zealand Pork after seven years. Leo Argent talks with Eric about his time at the organisation and what the future may hold.

National

Machinery & Products

JDLink Boost for NZ farms

Connectivity is widely recognised as one of the biggest challenges facing farmers, but it is now being overcome through the…

New generation Defender HD11

The all-new 2026 Can-Am Defender HD11 looks likely to raise the bar in the highly competitive side-by-side category.

» Latest Print Issues Online

Milking It

Buttery prize

OPINION: Westland Milk may have won the contract to supply butter to Costco NZ but Open Country Dairy is having…

Gene Bill rumours

OPINION: The Gene Technology Bill has divided the farming community with strong arguments on both the pros and cons of…

» Connect with Dairy News

» eNewsletter

Subscribe to our weekly newsletter